Hi all,
I'm new at the forum and i have a 2018 XC40 with sunroof, for about 6 months, and now it's making a weird noise that occurs when rains and only above 80kms/h.
It sounds like plastic vibrating and sometimes like water bubbling in some drain…
It sounds loud enough to be really annoying...
Anyone had the some problem?
Thank you all,
Roof noise with rain
-
- Posts: 228
- Joined: Thu Oct 04, 2018 3:36 pm
silvas wrote: ↑Sat Apr 06, 2019 4:46 pm Hi all,
I'm new at the forum and i have a 2018 XC40 with sunroof, for about 6 months, and now it's making a weird noise that occurs when rains and only above 80kms/h.
It sounds like plastic vibrating and sometimes like water bubbling in some drain…
It sounds loud enough to be really annoying...
Anyone had the some problem?
Thank you all,
Sorry to hear about that. My D3R with the panoramic roof is fine.
With the lovely weather this weekend I’ve had my roof open for first time in a while.
Anyway, noticed the rivet/screws on the wind deflector are rusted. That isn’t right surely. Also, the roof judders quite wildly when closing.
It’s in next week for the service but won’t lie this is beginning to p me off.
Anyway, noticed the rivet/screws on the wind deflector are rusted. That isn’t right surely. Also, the roof judders quite wildly when closing.
It’s in next week for the service but won’t lie this is beginning to p me off.
XC40 FE | D4 | Osmium Grey |19" wheels
-
- Posts: 30
- Joined: Sat Apr 28, 2018 1:30 pm
- Location: Perth,Scotland
Senwar, I’ve had the exact same problems as you describe, dealer replaced
the runners,seal and glass panel on my sunroof.
My water ingress(rusty screws) was caused by the mesh of the wind deflector
folding the wrong way(towards front of car)on closing and being sandwiched
between seal on glass and seal on the body work on front.
Also check seal outside on roof for misalignment or dips which can let water in,
caused by the shuddering.
the runners,seal and glass panel on my sunroof.
My water ingress(rusty screws) was caused by the mesh of the wind deflector
folding the wrong way(towards front of car)on closing and being sandwiched
between seal on glass and seal on the body work on front.
Also check seal outside on roof for misalignment or dips which can let water in,
caused by the shuddering.
XC40 FE Fusion Red ,19” Wheels ,No Skooshers, Delivered 02/06/18
Thanks for the info Doug. Very very helpful and I will raise this on Monday next week when the car is in.
Just been out to check and the roof does seem not to be flush on both sides (seems to be raised in middle slightly). Checked the mesh and it closes quite oddly - mesh goes partly to front but the plastic bit does go to rear. Was yours like that?
Just been out to check and the roof does seem not to be flush on both sides (seems to be raised in middle slightly). Checked the mesh and it closes quite oddly - mesh goes partly to front but the plastic bit does go to rear. Was yours like that?
XC40 FE | D4 | Osmium Grey |19" wheels
-
- Posts: 30
- Joined: Sat Apr 28, 2018 1:30 pm
- Location: Perth,Scotland
You could actually see about 2 inches of mesh sticking out between the 2
seals when the roof closed on my car.
Passenger side of my car above front passenger door, the seal was sitting about
2.5mm lower than roofline for about 3 inches.It appeared after it started shuddering
when closing.
seals when the roof closed on my car.
Passenger side of my car above front passenger door, the seal was sitting about
2.5mm lower than roofline for about 3 inches.It appeared after it started shuddering
when closing.
XC40 FE Fusion Red ,19” Wheels ,No Skooshers, Delivered 02/06/18